The Dodge Caravan is a passenger minivan manufactured by Chrysler and marketed under the Dodge brand. Introduced for model year 1984 and now in its fifth generation, the Caravan has been offered in short-wheelbase (1984-2007) and long-wheelbase (1987-present) variants, the latter as the Grand Caravan. The Grand Caravan is the sibling vehicle of the Chrysler Town & Country. It is manufactured with both manual and automatic transmission styles. The 2014 Dodge Grand Caravan is built in Windsor Assembly Plant in Windsor, Ontario, Canada.
First, drain the old oil by removing the drain plug and allowing the oil to drain into a pan. Then, replace the drain plug and remove the oil filter. Install a new oil filter by lubricating the gasket and screwing it onto the engine. Finally, add new oil to the engine through the oil fill cap.
Locate the brake fluid reservoir under the hood and check the fluid level by looking at the markings on the side of the reservoir. If the fluid level is low, add brake fluid until it reaches the recommended level. Be sure to use the correct type of brake fluid for your vehicle.
Start the engine and allow it to reach normal operating temperature. Shift the transmission through each gear and then back to park. Locate the transmission dipstick, remove it, and wipe it clean. Reinsert the dipstick and remove it again to check the fluid level. Add fluid if necessary.
Locate the air filter housing under the hood and remove the clips or screws securing the cover. Lift the cover off and remove the old air filter. Install the new air filter, making sure the rubber seal is seated properly. Replace the cover and secure it with the clips or screws.
First, remove the negative cable from the battery terminal, then remove the positive cable. Next, remove the battery hold-down clamp and lift the battery out of the tray. When installing the new battery, connect the positive cable first, then the negative cable, and secure the hold-down clamp.
Remove the wheel and locate the brake caliper. Use a C-clamp to compress the caliper piston, then remove the caliper bolts and lift the caliper off the rotor. Remove the old brake pads and install the new pads. Reinstall the caliper and tighten the bolts.
Locate the cabin air filter housing, which is typically under the dashboard on the passenger side. Remove the cover and take out the old filter. Install the new filter, making sure it is facing the correct direction. Replace the cover.
Locate the fuel filter under the vehicle and use a wrench to loosen the fuel lines. Remove the fuel filter and install the new filter, making sure the flow arrows are pointing in the correct direction. Tighten the fuel lines and start the engine to check for any leaks.
To replace the headlights on a Dodge Grand Caravan, locate the headlight assembly under the hood and remove the retaining clips or screws. Pull the assembly out of the vehicle and disconnect the wiring harness. Install the new headlight assembly by connecting the wiring harness and securing it with the retaining clips or screws.
Locate the belt routing diagram under the hood and use it as a guide to remove the old belt. Release the tension on the belt by using a wrench to turn the tensioner pulley. Remove the old belt and install the new belt, following the diagram. Use the wrench to release the tension on the tensioner pulley and ensure the belt is properly seated.
A grinding noise when braking in a Dodge Grand Caravan is typically caused by worn brake pads or rotors. The brake pads press against the rotors to slow the vehicle, and if either of these components are worn, they can produce a grinding noise.
The most common causes of overheating in a Dodge Grand Caravan are a malfunctioning thermostat, a leaking radiator, or a faulty water pump. The thermostat regulates the engine's temperature, the radiator cools the engine's coolant, and the water pump circulates the coolant through the engine. If any of these components are not functioning properly, the engine can overheat.
A misfiring engine in a Dodge Grand Caravan can be caused by several factors, including a faulty spark plug or ignition coil, a clogged fuel injector, or a vacuum leak. Check the spark plugs and ignition coils for wear or damage, inspect the fuel injectors for blockages, and check for any vacuum leaks in the engine.
A vibrating steering wheel in a Dodge Grand Caravan can be caused by several factors, including worn or unbalanced tires, a bent wheel, or worn suspension components. Check the tires for wear or damage, balance the tires if necessary, and inspect the suspension components for wear.
There are several reasons why a Dodge Grand Caravan may not start, including a dead battery, a faulty starter, a bad ignition switch, or a clogged fuel filter. Check the battery connections, listen for a clicking noise when turning the key, and inspect the fuel filter for blockages.
Get notified for new manuals?
We'll send you a quick email when a new Dodge Grand Caravan manual is added.
